Shutdown Problem: LCD TV Sylvania LD320SS8 | Electronics Repairguide Collection


Shutdown Problem: LCD TV Sylvania LD320SS8

lcd tv slyvania LD320SSB 


It is common to LCD television we for correction. Symptom of the problem is almost always turns on TV for a short time, “digital TV” appears in the lower right and then the TV goes off and returns to standby mode.
This type of error is almost always due to power failure or circuit inverter in most LCD TVs. Normally, I start by measuring the output voltages from the power source during the time that is to see if any tolerance or lack of starting the inverter circuit, control circuit ring welding cracks and check the capacitors on the supply side of raised ESR and secondary power filter control pico fuses and transformers is the inverter circuit, etc.. but this model I know that one of the transformers high voltage inverter circuit is often a secondary winding develops open, is usually a place of high-voltage transformer T1100.
lcd tv high voltage transformer
The first thing I do with this model is check all the secondary windings to see if any have opened by measuring there resistance, an open winding will have an infinite resistance or if you are using a DMM you will get an O.L. (Over Limit or Open Loop) reading. Each one of the HV transformers in this model TV has 2 secondary windings. 
 lcd tv primary winding

While the measuring of resistance, I find that none of the secondary windings were open, but what I noticed is that one of the secondary windings have a resistance much lower, so that all other I measured. All secondary windings have a resistance of between 522 and 527 ohm secondary winding and the suspect had a resistance of 495.4 ohms, about 30 ohms is less than the rest. It was a very good indication that the secondary winding was cut short. This is great on the test of HV transformers in most LCD TVs, to compare the test results of a transformer to another, usually a single high voltage transformers will go wrong, and it will be easy to identify when tested and compared against the other.

lcd television transformer
lcd tv transformer
Upon closer inspection of the transformer with the shorted secondary winding the burned area of the secondary winding was noted as well, confirming without a doubt that the transformer was faulty and sure enough it was T1100, the transformer that we normally replace in this model but always for an open secondary winding but this time obviously the winding was shorted. Most likely what typically happens is the secondary coil shorts and then excess current is drawn as the resistance of the coil drops which in turn causes the coil to heat up and burn causing it to go open, but in this case the coil shorted and the TV shutdown before it had a chance to open. 
lcd television high voltage transformer
lcd television transformer
After the HV transformer was replaced with a new one, part number LTZ2PC0MS008(substitute for 3PC0XB001) the TV turned on and functioned properly once again.
The LTZ2PC0MS008 can be found at Electronica USA  along with many other electronics components. 
Related Posts Plugin for WordPress, Blogger...
Posted by 7 Responses
 

Free Email Newsletter

Stay Updates with this Blog. Get Free email newsletter updates..

And then confirm your email subcription

   

7 Comments to “Shutdown Problem: LCD TV Sylvania LD320SS8”

  1. Christopher says:

    It’s a pity you don’t have a donate button! I’d most certainly donate to this superb blog! I guess for now i’ll settle for book-marking and adding your RSS feed to my Google account. I look forward to fresh updates and will talk about this blog with my Facebook group. Chat soon!

  2. Paige says:

    It s actually a great and useful piece of info. I am glad that you simply shared this helpful information with us. Please stay us up to date like this. Thank you for sharing.

  3. Thanks for dropping, the site is still on developing process, I will add donate button after some development

  4. jojogreg says:

    This is a great info..a big help to beginners like me..stay tune to your blog..

  5. Elmo Sabados says:

    Just Googled and read through the whole article and i must really have to say that me and my husband loved reading your submit. I liked your site because in the straightforward language you used to explain things here. Now i’m able to stop my research having found my answer in this brilliant article. We bookmarked and will regularly check more quality tips to come from your site. Many thanks alot.

  6. Article needs a +1 button.

  7. Armand Poto says:

    I just want to say I am new to blogging and honestly liked this page. Probably I’m going to bookmark your website . You certainly have great stories. Thanks for sharing with us your blog.

Leave your comment here:

3087 Views
 
ADS
Follow Us and Stay Connected



Recommend on Google
STATISTICS
Technology & Computers - Top Blogs Philippines Active Search Results Blog Directory for the Philippines
Google PageRank Checker Powered by  MyPagerank.Net